krew

Site Founder
Administrator
Messages
3,686
Reactions
5,670
19-10-10-lexus-ev-concept-teaser.jpg

Lexus has just released a teaser image of their upcoming electric vehicle concept debuting at the Tokyo Motor Show later this month. A short video was also posted on Instagram:

This lines up with an earlier sketch published by Autocar last month:
19-09-29-lexus-ev-concept.jpg

The concept is expected to be a small city car with in-wheel electric motors for power. While it will be presented as a simple design study, Lexus has strongly hinted some of the design shown will reach production in the coming years.
The full press release accompanying the teaser image:

Leveraging continued advances in technologies such as electrification and autonomous driving, the electrified concept offers a glimpse into Lexus’ future vision, which caters to...

Continue reading...
 
Last edited:

ssun30

Expert
Messages
3,326
Reactions
7,418
That's not what they said about the Prius twenty years ago.

They did not expect the Prius to be dependable, environmental friendly, or safe on Day 1. It was full of quirks and didn't work well until two generations later. It lived off subsidies for years before becoming a profitable program.

They need to look back at how they achieved dominance in hybrids when they consider their approach to EVs.

Yes, Lexus needs to make its parent company absorb all the risk. But by that logic they shouldn't rush the LS-FC...
 
Last edited:

krew

Site Founder
Administrator
Messages
3,686
Reactions
5,670
They did not expect the Prius to be dependable, environmental friendly, or safe on Day 1. It was full of quirks and didn't work well until two generations later. It lived off subsidies for years before becoming a profitable program.

Excellent point -- Lexus or Toyota should have launched an EV pilot program, with production numbers similar to the Mirai. Would go a long way to showing some experience with pure electric, while generating some buzz (haha). A limited-run Lexus EV would be a hot ticket.
 

mikeavelli

Moderator
Messages
6,775
Reactions
15,141
Tesla's volume is very tiny, if we are talking Toyota/Lexus numbers it would be a staggering amount in comparison. There still is not widespread infrastructure as well. Where do you go to charge up?

I think a few of us said though, an EV would be right up Lexus alley in regards to quiet, less NVH etc....
 

ydooby

Follower
Messages
124
Reactions
256
Forget about pure EVs. Make plugin hybrids first. The Prius plugin is on its 2nd generation already. Where's Lexus' version?

BMW sold 942 5-series plugins last month. At 22% of the total 5-series sales volume of 4,311 for the same month, it is a WAY better take rate than any of Lexus' hybrid models vs non-hybrid models.

Lexus is missing the boat by not offering a plugin model. With plugins one can always charge at home daily while not worrying about finding charging stations when going longer distances on occasions. It is the best of both worlds and people who can afford luxury cars are more likely to afford the premium required by plugin hybrids.
 
Last edited:
Messages
53
Reactions
74
Forget about pure EVs. Make plugin hybrids first.

I used to think the exact same way too.
However, now with further insight, I can see that presently there are so many different engine formats, with simply no perfect format.

Atmospheric still good, but thirsty and emissions.

Small capacity turbos great, but the lag.

Turbo-diesels great, but the NVH, 4500 rpm redline, and the carcinogenic particle dust pollution.

Electric turbos no lag, but they do have certain cons like a big heavy 48 Volt battery to power the electric motor.
Furthermore, electric turbos free of lag - is rendered almost unnecessary - when electric motors with instant torque are already used in hybrids, and plug-in hybrids.

Gasoline-electric hybrids with the new generation of batteries efficiently sandwiched between the rear seat base and fuel tank great by not hindering trunk space, but still certain limitations like little electric propulsion & poor electric range.

danh-gia-xe-2019-lex-cdd7_wm.jpg


Plug-in hybrids great, but that huge 3x size battery pack in the rear overhang dramatically reduces trunk volume, adds enormous weight to the tail, and with no room for a spare tire compartment, it forces run flat tires, or a tire repair kit.

BMW-330e.3.jpg


EV great, but the lithium ion batteries have a lot of limitations.
EV with solid state batteries great, but tech won't arrive till at least 2025 or beyond.

It's terrible that there are so many different choices, each with their pros and cons, yet no perfect choice.

Someone who rarely drives in peak hour traffic like me could prefer a conventional hybrid with a tiny battery pack sandwiched beneath the rear seat base for a full size trunk and conventional soft riding tires.
However, someone who daily drives in peak hour traffic may prefer a plug-in hybrid with a triple size battery pack so that they have a tremendous electric range, yet they would have to live with the tiny trunk size, the heavy weight of the triple size battery pack in the rear overhang, and either run flat tires, or conventional soft riding tires with only a tire repair can kit.

I dare say the Europe with its limited land size & hi population density may prefer plug-in hybrids & EV's.
While the USA with its huge land area may prefer atmospheric, small capacity turbos, electric turbos with no lag, or Gen III hybrids with the battery pack efficiently sandwiched between the rear seat base & the fuek tank.

Gen I & II hybrids with the battery pack behind the rear seat back rest & in the rear overhang is now passe...
 
Last edited:

ydooby

Follower
Messages
124
Reactions
256
Large capacity battery in the rear overhang plug-in hybrids great, but that 3x size battery pack in the rear overhang reduces trunk volume, adds enormous weight, and forces run flat tires, or a tire repair kit.
True, gotta agree. The loss of trunk space directly negates its benefit in extended road trips where luggage capacity actually matters.

Perhaps the holy grail is really Mazda's Skyactiv-X, with its targeted 56% thermal efficiency. (Toyota just bragged about its 40% thermal efficiency with its newly released Dynamic Force 2.0L engine, or 41% with hybrid.)
 

mikeavelli

Moderator
Messages
6,775
Reactions
15,141
Forget about pure EVs. Make plugin hybrids first. The Prius plugin is on its 2nd generation already. Where's Lexus' version?

BMW sold 942 5-series plugins last month. At 22% of the total 5-series sales volume of 4,311 for the same month, it is a WAY better take rate than any of Lexus' hybrid models vs non-hybrid models.

Lexus is missing the boat by not offering a plugin model. With plugins one can always charge at home daily while not worrying about finding charging stations when going longer distances on occasions. It is the best of both worlds and people who can afford luxury cars are more likely to afford the premium required by plugin hybrids.

Interesting numbers, thanks for posting that.
 

ssun30

Expert
Messages
3,326
Reactions
7,418
The 530e has like 16 miles of EV range which is barely usable. People buy it for the tax credit.

Here are the problems with PHVs:
>>Since they have a small battery designed for a modest EV range, the batteries go through much more charging cycles over the same mileage.
>>To have a higher cycle rating, the battery pack needs to be under-SOCed. Available energy is thus even less than the already low capacity.
>>The car needs to be drivable on electric power alone, so the battery pack needs very high power for its small size. The individual cells need to be designed for power density. Doing so necessarily reduces the energy density of the cell. (electro-chemistry 101: energy density and power density are mutually exclusive)
>>Most PHVs are designed with little power reserve (usually 70kW max power), so the battery will operate closer to its maximum rated power in daily driving. Therefore the cells need more cooling than in a BEV.
>>Having more cooling means lower packaging efficiency. Therefore the battery pack needs to be larger and heavier compared to a BEV pack (for the same capacity, of course).

To give a numerical example. The Prius Prime's battery pack weighs 118kg, with 8.8kWh nominal capacity and 70kW nominal power. This would give an energy density of 75Wh/kg and a power density of 590W/kg at the pack level. The Tesla Model S 85 has a 540kg pack with 85kWh nominal capacity and 400kW maximum power. The energy density is 157Wh/kg and the power density is 740W/kg*. Obviously Tesla has superior technology here, but this just shows how suboptimal PHV packs are. You cannot downsize the Model S pack by a factor of 5 and put it in a Prius Prime, since the battery will die after like 50,000km.

*The Model S pack has higher power density because it only needs to operate at maximum power for a short duration, whereas the Prime's pack is expected to operate at 70kW for much longer. Also the Model S pack has closer to 80% packaging efficiency while the Prime has less than 60%.

It's industry consensus that PHVs will be the major form of electrification in the first half of 2020s and continue to be the mainstream EV until 2030, due to the cost advantage over pure BEVs alone. However so far battery technology has not allowed a balanced PHV battery pack design that does not intrude cabin or cargo space. The situation will get better in the next few years.
 

maiaramdan

Expert
Messages
1,806
Reactions
1,416
@ssun30
And because that more charging cycles exactly I prefer the HEV over PHEV
Just use it in city and charge it with braking, this is the main Toyota positive point in Europe though,

Honestly who needs EV at the highway, using the EV at the start and at the congestion in the city is way logic
 

isanatori

Follower
Messages
103
Reactions
108
That's not what they said about the Prius twenty years ago.

They did not expect the Prius to be dependable, environmental friendly, or safe on Day 1. It was full of quirks and didn't work well until two generations later. It lived off subsidies for years before becoming a profitable program.

They need to look back at how they achieved dominance in hybrids when they consider their approach to EVs.

Yes, Lexus needs to make its parent company absorb all the risk. But by that logic they shouldn't rush the LS-FC...
1) When prius went to US, it cost $19k MSRP after incentives and had a curb weight less than 2900 lbs. It was based on vitz platform though. It had been being built in a unique platform specifically designed for the prius, that was costly to begin with. Gen 1 still gets gen 4 traction battery modules!
2) Gen 2 had been being built on the same platform with the gasoline-only Toyotas.
2nd gen smokes both 3rd and 4th gen prius performance wise.
3) 3rd gen is the least reliable of all gens.
4) Gen 4 MSRP $25k (C platform)

Yet, both 1&2 were characterized immature. The traction battery is an environmental nightmare, still about the same as the last gen though.

Plug in and EV have some immature drawbacks too.
Excessive weight that handicaps driving dynamics and burning fossil fuels too.
They are expensive and their battery is an even worse environmental nightmare than standard hybrid Nimh battery! Long charging time, energy loss when charging faster, unstable renewable sources for BEV(think about the huge impact from natural disasters).

Toyota has spent huge resources on hydrogen cars. The camry hybrid powertrain is basically identical to the hydrogen Mirai, except the fuel tanks and the ICE/FC stack. Prius was the first step for realizing hydrogen cars. That's why it was named prius.

Only a looser would have change route from such an effort, just because EV has gained more attention.

In the worst scenario, Toyota will struggle with FCEV against BEV, just like it had been struggling with hybrids against diesel 20 years ago.
 

ssun30

Expert
Messages
3,326
Reactions
7,418
@ssun30
And because that more charging cycles exactly I prefer the HEV over PHEV
Just use it in city and charge it with braking, this is the main Toyota positive point in Europe though,

Honestly who needs EV at the highway, using the EV at the start and at the congestion in the city is way logic

Yes. It's truly impressive how much Prius can stay in EV mode and minimize ICE on-time in urban commute. IIRC there was a test in Rome in which the Prius was in EV mode for over 60% of the time. Toyota has truly mastered energy management of HEV in this generation.
 

Joaquin Ruhi

Moderator
Messages
1,529
Reactions
2,434
Is this source legit?

During a Lexus media event in Costa Rica, we learned the company plans to reveal an all-electric concept model at the 2019 Tokyo Motor Show in late October.
I'd say so. I certainly knew of the Lexus media event in Costa Rica through fellow Miami-based automotive journalists, but, to me, the timing was unclear and that's the first published story I see regarding the event. Between that and a Digital Trends story citing Lexus VP Koji Sato, it seems that Lexus is dropping hints of some sort of groundbreaking concept coming to the 2019 Tokyo Motor Show.
 

mediumhot

Follower
Messages
456
Reactions
606
There is some talk on the front page about in-wheel electric motors as direction they want Lexus to head in. Quite a tricky path as there has been development of such concepts since 2005 and there is still no breakthrough. Mitsubishi thought it was an easy way to make ultimate AWD setup for their Evo program and went very deep into in-wheel motors but so far nothing came out of it.